Crews work to replace and refit a water filter system aboard the Puyallup at the Eagle Harbor Maintenance Facility in Bainbridge on October 31, 2019. (Kevin Clark / The Herald)

Crews work to replace and refit a water filter system aboard the Puyallup at the Eagle Harbor Maintenance Facility in Bainbridge on October 31, 2019. (Kevin Clark / The Herald)

Washington State Ferries plans for an electric-hybrid fleet

It will be a literal sea change for the nation’s biggest system — and a technically ambitious one.

As the ferry boat pulls away from the dock, the rumble from the engine grows louder and vibrations rattle passengers on the sun deck.

A quieter, cleaner ride could be on the horizon for people and marine life as Washington State Ferries embarks on an experimental plan to transition the fleet from diesel to electric power.

“It’s new territory, a lot of stuff depends on what we think we can do,” said Mark Nitchman, a chief engineer for state ferries. “But we should espouse what we stand for and lead the way.”

To accomplish this ambitious plan, the agency is starting by converting the three largest ferries in the fleet from diesel to hybrid-electric propulsion. The three Jumbo Mark II boats — the Tacoma, Puyallup and Wenatchee — are the biggest fuel consumers, burning together 14,000 gallons of diesel a day. They usually run on the Seattle-to-Bainbridge and Edmonds-to-Kingston routes.

At the same time, the state has contracted Seattle-based Vigor to build up to five electric-hybrid Olympic class ferry boats, which the state hopes to put into service from 2022 through 2028. They are smaller than the Jumbo Mark II boats and are estimated to cost between $140 million to $180 million per vessel.

This is all part of Gov. Jay Inslee’s goal of moving toward a zero-emissions fleet, which today is the largest consumer of diesel fuel in the state, using over 18 million gallons of diesel a year, according to the state.

Shaft alley aboard the Puyallup at the Eagle Harbor Maintenance Facility in Bainbridge on October 31, 2019. (Kevin Clark / The Herald)

Shaft alley aboard the Puyallup at the Eagle Harbor Maintenance Facility in Bainbridge on October 31, 2019. (Kevin Clark / The Herald)

Washington State Ferries is leading the way to electric ferries that haul cars and passengers, Nitchman said. And if all goes well, the state could operate the biggest hybrid auto-transporting ferries anywhere in the country.

Replacing the diesel engines in the massive boats with battery packs will be no easy task. Nitchman likens the conversion process to major surgery.

“There’s a lot to learn. We’ve never run a hybrid boat before,” he said. “I’m excited to be diving into this technology.”

Last month, the state selected Siemens, a global company that specializes in power generation, to do the conversion work. Planning work will continue through 2020 with construction likely to begin in 2021.

The plan is to remove two of four diesel engines, which spin a generator to create electricity, and replace them with large battery packs to power the motors. Money from the Volkswagen settlement is paying for a large chunk of converting the first boat, which is estimated to cost about $40 million.

Moving toward this system, boats will not only emit fewer pollutants and consume less fuel but also have fewer parts, saving on labor costs, Nitchman said.

“But there is no free lunch,” he added.

Batteries must be replaced every four to five years, and crews will have to learn a new technology.

Mark Nitchman, a chief engineer for Washington State Ferries, said installing hybrid engines on the vessels would be a great legacy to leave before retiring. (Kevin Clark / The Herald)

Mark Nitchman, a chief engineer for Washington State Ferries, said installing hybrid engines on the vessels would be a great legacy to leave before retiring. (Kevin Clark / The Herald)

The conversion is the less-complicated portion, said Ian Sterling, a state ferries spokesperson. To be able to run an electric fleet, charging stations have to be designed and built, and the state has to coordinate that work with various utilities providers.

Washington State Ferries set a goal in its 2040 long range plan that in 20 years, 22 of 26 boats in the fleet would be plug-in hybrids and most terminals would have charging stations.

Until the charging infrastructure is installed, the remaining diesel engines will charge the batteries. Only one is needed to do this, so running as a hybrid system will still reduce emissions, according to Nitchman.

Once charging stations are up and running, the agency assumes charging times can be limited to about 20 minutes, the time it takes to offload and onload many boats.

That’s when the real savings will be seen.

“There are savings even before shore charging, just not as much,” Sterling said.

As the big boats are being converted, the state also is building new hybrid boats. They will work much the same way as the converted boats with diesel engines powering the batteries. The diesel engines will then be used as a back-up system.

A lot of the details for both projects are still being worked out.

“It will take a long time to be all-electric, but that’s ultimately where we want to be,” Sterling said.

Got a question? Email me at streetsmarts@heraldnet.com or call 425-374-4165. Please include your name and city of residence.


Talk to us

Please share your story tips by emailing editor@seattleweekly.com.

Crews work to replace and refit a water filter system aboard the Puyallup at the Eagle Harbor Maintenance Facility in Bainbridge on October 31, 2019. (Kevin Clark / The Herald)

Crews work to replace and refit a water filter system aboard the Puyallup at the Eagle Harbor Maintenance Facility in Bainbridge on October 31, 2019. (Kevin Clark / The Herald)

More in News & Comment

File photo.
COVID testing centers shut down for lack of business license

Center for Covid Control announced Jan. 13 it would close all of its locations for a week.

During a news conference Thursday, Washington Gov. Jay Inslee explains the deployment of the National Guard to hospitals to assist with the coronavirus surge. (TVW) 20220113
Surgeries paused, National Guard deployed to assist hospitals

King County health officials say 1 in 7 ICU and acute-care hospital beds are occupied by a COVID patient.

Credit: Pixabay
Prosecutor alleges Seattle man recorded Muckleshoot Casino employee using toilet

The Auburn Police Department reports that a Seattle man used his cell… Continue reading

Screenshot from City of Kent Facebook Page
Trash piles up in King County neighborhoods after agency postpones service for weeks

Collection company initially cited weather as the reason, but now a strike interferes.

Screenshot from King County Council meeting
King County Council approves new leadership, committee structure and assignments

The leadership positions and committee assignments will last through 2022.

Surveillance photos of the 28-year-old Seattle man who has been arrested and charged with 12 counts of first-degree robbery. (Photos taken from charging documents)
Seattle man arrested after allegedly committing a dozen King County robberies

The 28-year-old is believed to have conducted robberies in Seattle, Bellevue and Federal Way.

File photo
Widespread burnout among healthcare workers prompts change at hospitals

Healthcare workers unions are supporting HB 1868 and companion bill SB 5715.

Bellevue police standoff. File photo
Washington Democrats introduce bills clarifying police reforms

One deals with mental health response and the other deals with less-lethal weapons.

Most Read